Succinic acid
Succinic acid
disodium succinate
Phthalocyanine pigment
Compound dyes
Compound green
Composite blue
Succinic acid(cas:110-15-6) Production From Synthetic Sugar Mixture
Release time:2016/7/11 20:40:17

A fermentation protocol was developed utilizing AFP 184 in combination with a synthetic sugar feedstock. As can be noted on FIG. 3, succinate production was rapid up to 80 hours, and plataued somewhat before reaching a final high of 60 g/L after approximately 140 hours.

The fermentation medium contained the following components: Difco yeast extract 5 g/L, tryptone 10 g/L, (NH4)2SO4 2 g/L, MgSO4—7H2O 0.2 g/L, NaCl 10 g/L, K2HPO4 7 g/L,KH2PO4 3 g/L, glucose 7.6 g/L, xylose 1.85 g/L, and kanamycin 30 mg/L. The medium with all of the components except the antibiotic was autoclaved at 121° C. for 20 minutes. Kanamycin then was added upon cooling. This fermentation medium was used for both the inoculum flasks and the one-liter fermenter. For the inoculum, 50 mL medium was placed in a 250-mL flask and inoculated with 0.2 mL of the AFP184 stock culture which was maintained in 30% glycerol and at ?70° C. The flask was incubated in a incubator shaker at 37° C. and 250 rpm overnight (about 16 hours). The entire flask contents then were used to inoculate the fermenter which was maintained at 37° C.

The medium in the fermenter was aerated to allow fast growth of the organism. After six hours when the required cell mass was achieved, the following actions were taken:

1. Air was turned off to exert anaerobic conditions, which would initiate production of succinic acid;
2. Carbon dioxide gas was sparged into the medium at a rate of 0.03 mL per minute; and

3. A feed solution which contained 400 g/L glucose and 84 g/L xylose was added to the fermenter to achieve a total sugar concentration of 50 g/L in the fermentation medium.

During the course of the experiment, when the sugar concentration in the fermenter was low, more feed was added to provide sufficient substrates for succinic acid(cas:110-15-6) production. As the cells produced succinic acid(cas:110-15-6), the pH dropped. It was maintained at pH 6.5 by addition of a 1.5 M Na2CO3 solution through the action of an automatic pH controller. Samples were taken at intervals and analyzed for optical density, glucose, xylose,succinic acid(cas:110-15-6), acetic acid, lactic acid, and ethanol.

Table 3, infra, and FIG. 3 illustrate the succinic acid(cas:110-15-6) production resulting from the utilization of the synthetic sugar mixture.As can be noted in a comparison between Example 1 and Example 2, succinate production of the mutant was equivalent (see time points 120 and 122 of Table 2 and 3, respectively) when industrial hydrolysate was used versus when the synthetic feedstock was used. This result illustrates the robust character of the invented protocol in that any toxic materials inherent with industrial grade hydrolysates did not degrade the yield.

Return >> 
Home | About Us | Products | Honors | Facility | Order | Contact | News | 中文版
Copyright(C)2013, Anhui Sunsing Chemicals Co.,Ltd. All Rights Reserved.Supported by Lookchem Copyright Notice